Haybusa Parts and Service Member Support

Author Topic: Resurrecting an 01  (Read 246 times)

Offline NiteRunner

  • Rider
  • ***
  • Posts: 148
  • Gender: Male
Resurrecting an 01
« on: August 31, 2020, 03:33:45 AM »
My beautiful, clean 01 has been in long term storage last eight years.
My bud was supposed to ride it, but he ended up out of the country too.

Obviously she needs some TLC and freshening up.
Oil changed, brake system flushed/cleaned, (forgot how much the front drags)
New plugs, maybe a throttle body sync, new coolant?
Took her for a rip (big smiles) and she ran smooth, then rough and almost quit, (didnít think Iíd get home).
Added fresh gas, no change.
Stored in Florida, so Iím concerned about rust in the tank.
Hard to get a flashlight in there, but didnít look too bad.

Some old mods that might need addressing;
Full Yosh race, single pipe
Incomplete airbox flapper mod, (didnít seal the vacuum hole)
Old Power Commander II with serial port. Green LED was lit, but who knows if the map is still loaded, (unplugged for now)

Figure Iíll do as much as I can to save $$ and then get her tuned to former glory.

Havenít been here in a long time. Comments and suggestions are greatly appreciated.
Currently in SoCal
« Last Edit: August 31, 2020, 03:37:28 AM by NiteRunner »
Whoa, this thing has brakes too!?
01 Blue/Silver
08 DL650

Offline ADMIN

  • Administrator
  • Post Master
  • *****
  • Posts: 1529
Re: Resurrecting an 01
« Reply #1 on: August 31, 2020, 01:58:41 PM »
Have you checked the fuel filter? It's a good idea to drain and add fresh fuel before starting something after long storage.
Closed course. Professional rider. Do not attempt.

Still privately owned and operated by Hayabusa owner enthusiasts. 2002, small  a/a kit, CF body

SuzukiHayabusa.org's Fastest street mod bike member:
WildBro
William Bill Warner
311.945 MPH